Experimental and Numerical Modeling of Soft Soil Improvement using Compacted Lime Mortar Columns

Author
G. Poorebrahimi
University of Kerman
Abstract
Abstract:
Construction of roads, railways and other engineering structures over soft soils usually involves
consideration of excessive settlements, deformations, and stability problems. To avoid or reduce such problems, several ground improvement techniques are available including the use of column type
elements. Stone columns represent the most known column-type techniques for improving soft soils. It
is well established that the stone columns derive their load carrying capacity from the lateral confining
pressure provided by surrounding soil. Since intermediate layers consisting of organic or very soft to
soft soils can not provide proper lateral support to the stone columns, the external lateral support can
be replaced in these columns by an internal bond between the stones. This can be done by applying
binders such as lime during the installation of the stone/gravel columns, which bind the gravels
together and form a solid column. An alternative method is suggested in the present study to improve
the performance of stone columns in soft soils by using compacted lime mortar columns. Laboratory
tests are carried out on large scale composite specimens composing of compacted lime mortar columns
and soft clay surrounding it. Experiments were carried out on the both end bearing and floating
columns with dimensions of 100 mm diameter, and 600 mm height. The columns were surrounded by
soft soil in cylindrical tanks of 600 and 800 mm height, and a diameter varying from 230 to 320 mm to
represent the required unit cell area of soft soil around each column assuming triangular pattern of
installation of columns. In the field, the entire of the column treated ground will be subjected to
loading from the superstructure. The same was simulated in the laboratory by loading the entire area
of the specimen to study the stiffness of improved ground with regard to the influence of different
parameters such as: area ratio (as the ratio of the area of the column (A
S
) to the total area within the
unit cell (A)), and shear strength of the clay. Finite element analyses have also been performed with

the software package PLAXIS V 8.2 using 15-noded triangular elements. Tests results show that

compacted lime mortar columns exhibit a stiffer and stronger response compared to conventional

stone columns installed in soft soils. These columns improve the load carrying capacity and decrease

the settlement of soft soils. The performance of these columns is significantly enhanced by increasing

the area ratio. However, when the area ratio exceeds 15%, the rate of increment of the load carrying

capacity is negligible. When the entire area of the composite specimens is loaded, because of the

confining effect of the boundary of the unit cell, failure does not take place even for settlement as high

as 15 mm. Comparison of numerical and experimental data shows a good agreement between the

results.

Keywords

مهرابی داودآبادی، م.، و توفیق، م. م. ؛ "استفاده از آنالیز ]
ابعادی بهمنظور تبدیل نتایج آزمایشگاهی ستون سنگی
به ابعاد واقعی"؛ پایان نامه کارشناسی ارشد، دانشگاه
39 و ، شهید باهنر کرمان، کرمان، 1389 ، صفحات 8
.40
[2] Engelhardt, K., Flynn, W. A., and Bayuk, A. A.;
"Vibro- replacement method to strengthen cohesive
soils in situ"; ASCE National Structure Engineering
Meeting, Cincinnati, 1974.
[3] Shahu, J. T., Hayashi, S., and Madhav, M. R.;
"Analysis of soft ground reinforced by nonhomogeneous
granular pile- mat system"; Lowland
Technology International Journal, Vol. 2, No. 2, pp.
71–82, 2000.
[4] Mitchell, J. K., and Huber, T. R.; "Performance of a
stone column foundation" ; Journal of Geotechnical
and Geoenvironmental Engineering (ASCE), Vol. 111,
No. 2, pp. 205- 223, 1985.
[5] Han, J., and Ye, S. L.; "Performance of stone column
reinforced foundations - a case study"; Journal of
Geotechnical Investigation and Surveying, No. 5, 1990
(in Chinese).
[6] Han, J., and Ye, S. L. ; "Measured stresses and pore
water pressures in the stone column reinforced
foundation under a building loading" ; Journal of
Geotechnical Engineering, Vol. 15, No. 5, 1993 (in
Chinese).
[7] Kamon, M.; "Recent developments of soil
improvement"; Proceedings of International
Symposium on Soil Improvement and Pile Foundation,
Nanjing, China, Vol. I, pp. 1–16, 1992.
[8] Hu, W.; "Physical modeling of group behavior of stone
column foundations"; Ph.D. Thesis, University of
Glasgow, Glasgow, Scotland, 1995.
[9] Ambily, A. P., and Gandhi, S. R.; "Behavior of stone
columns based on experimental and FEM analysis";
Journal of Geotechnical and Geoenvironmental
Engineering (ASCE), Vol. 133, No. 4, pp. 405- 415,
2007.
[10] DiMaggio, J. A.; " Stone columns for highway
construction"; Technical Report No. FHWA-DP-46-
1, U.S. Department of Transport, Federal Highway
Administration, 1978.
[11] Wu, C. S., and Hong, Y. S.; "The behavior of a
laminated reinforced granular column"; Geotextiles
and Geomembranes, Vol. 26, pp. 302–316, 2008.
[12] Wu, C. S., Hong, Y. S., and Lin, S. C.; "Axial stressstrain
relation of encapsulated granular column" ;
Computers and Geotechnics, Vol. 36, pp. 226–240,
2009.
[13] Kempfert, H. G., and Gebreselassie B.; "Excavations
and Foundations in Soft Soils"; Springer Press,
Berlin, 2006.
[14] Indian Standard (IS); "Indian standard code of
practice for design and construction for ground
improvement guideline"; Part 1: Stone columns, IS
15284, New Dehli, India, 2003.
[15] McKelvey, D., Sivakumar, V., Bell, A., and Graham,
J.; "Modeling vibrated stone columns on soft clay";
Geotechnical Engineering Journal, Vol. 157, No. 3,
pp. 137- 149, 2004.
[16] FGSV (Forschungsgesellschaft f. Straβen- und
Verkehrswesen); "Merkblatt für die
Untergrundverbesserung durch Tiefenrüttler"; Klön,
1979.
[17] Gniel, J., and Bouazza, A.; "Improvement of soft
soils using geogrid encased stone columns";
Geotextiles and Geomembranes, Vol. 27, No. 3, pp.
167–175, 2009.
[18] Kempfert, H. G.; "Ground improvement methods
with special emphasis on column-type techniques";
In: Proceedings of International Workshop on
Geotechnics of Soft Soils- theory and practice, pp.
101–112, 2003.
[19] Malekpoor, M. R., and Toufigh, M. M.; "Laboratory
study of soft soil improvement using lime mortar-
(well graded) soil columns"; Geotechnical Testing
Journal (ASTM), Vo. 16, No. 3, pp. 1-11, 2010.
[20] Pribe, H. J.; "The design of vibro replacement";
Ground Engineering, Vol. 28, No. 12, pp. 31- 37,
1995.
[21] Groughnour, R. R. ; "Settlement of vertically loaded
stone columns in soft ground"; Proceeding of the
eighth European Conference on Soil Mechanics, and
Foundation Engineering, Helsinki, Finland, pp. 235-
240, 1983.
[22] Shivashankar, R. D., Dheerendra M. R., Sitaram N.,
and Rajathkumar, V. ; "Experimental studies on
behavior of stone columns in layered soils";
Geotechnical Geological Engineering, Vol. 29, pp.
749- 757, 2011.
[23] Brinkgreve, R. B. J., " Plaxis user’s manual- version
8.2", Delft University of Technology and PLAXIS
b.v., The Netherlands, ISBN 905895088, 2002.
[24] ASTM D1557; "Test method for laboratory
compaction characteristics of soil using modified
effort"; Annual Book of ASTM Standards, ASTM
International, West Conshohocken, PA, 2000.
[25] Wood, D. M., Hu, W., and Nash D. F. T.; "Group
effects in stone column foundations: model tests";
Geotechnique, Vol. 50, No. 6, pp. 689- 698, 2000
Modares Civil Engineering journal
Volume 14, Issue 2
July and August 2014
Pages 129-141